2 25, 30wt. 2 25, 30wt KARAKTERISTIK MIKROSTRUKTUR DAN KONDUKTIVITAS LISTRIK CORDIERITE (2MgO.2Al2O3.5SiO2) BERBASIS SILIKA SEKAM PADI DENGAN PENAMBAHAN ALUMINA (Al2O3) (0, 20, 25, 30wt%)
ii
ABSTRACT CHARACTERIZATION OF MICROSTRUCTURE AND ELECTRIC
CONDUCTIVITY OF CORDIERITE 2MgO.2Al
2
O
3
.5SiO
2
BASED RICE HUSK SILICA WITH THE ADDITION OF ALUMINA Al
2
O
3
0, 20, 25, 30wt.
BY UMI ROHMAH
This study has been carried the synthesis and characterization of cordierite of based rice husk silica
with the addition of alumina as much as 0, 20, 25 and 30wt. Manufacture of cordierite using MgO and Al
2
O
3
materials and silica from rice husk are extracted with sol-gel method using 5 KOH solution and 10 HCl. The method
used is the method of solid state reaction and sintering at 1200°C with a holding time for 3 hours. Physical test had been conducted on shrinkage, density and porosity,
while the analysis of the microstructure characteristics and elemental composition used SEM EDS, as well as electrical conductivity test used LCR meter. In this study
the electrical conductivity values obtained between 7.9x10
-9
- 4.6x10
-6
Scm, so that the material can be classified as an insulator. The conductivity value decreases due
to the addition of alumina percentage.
Keywords : Cordierite, Rice Husk Silica, Sol-Gel, Solid State Reaction.
i
ABSTRAK KARAKTERISTIK MIKROSTRUKTUR DAN KONDUKTIVITAS
LISTRIK CORDIERITE 2MgO.2Al
2
O
3
.5SiO
2
BERBASIS SILIKA SEKAM PADI DENGAN PENAMBAHAN ALUMINA Al
2
O
3
0, 20, 25, 30wt
Oleh Umi Rohmah
Telah dilakukan sintesis dan karakterisasi cordierite berbasis silika sekam padi dengan penambahan alumina sebanyak 0, 20, 25 dan 30wt. Pembuatan
cordierite menggunakan bahan MgO dan Al
2
O
3
dari pasaran dan silika dari sekam padi yang diekstraksi dengan metode sol-gel menggunakan larutan KOH 5 dan
HCl 10. Metode yang digunakan adalah metode reaksi padatan Solid State Reaction
dan disintering pada suhu 1200°C dengan waktu tahan selama 3 jam. Pengujian fisis yang dilakukan meliputi penyusutan, densitas dan porositas,
sedangkan analisis karakteristik mikrostruktur dan komposisi unsur menggunakan SEMEDS, serta uji konduktivitas listrik menggunakan LCR meter.
Pada penelitian ini diperoleh nilai konduktivitas listrik antara 7.9x10
-9
– 4.6x10
-6
Scm, sehingga bahan dapat digolongkan sebagai isolator. Nilai konduktivitas ini semakin menurun seiring dengan penambahan persentase alumina.
Kata Kunci : Cordierite, Silika Sekam Padi, Sol-Gel, Solid State Reaction.
KARAKTERISTIK MIKROSTRUKTUR DAN KONDUKTIVITAS LISTRIK
CORDIERITE 2MgO.2Al
2
O
3
.5SiO
2
BERBASIS SILIKA SEKAM PADI DENGAN PENAMBAHAN ALUMINA Al
2
O
3
0, 20, 25, 30wt